|
08-07-2010, 08:58 AM
|
#1
|
Member
Join Date: Aug 2007
Posts: 89
|
Musty Smell
I know this is a long shot but here goes. We have had a musty smell in our 38Rl3 since we have owned it new. My son is using the rig this weekend and he noticed it. He says it is most noticeable around the frig. The rig has been closed up for about 1 month. all sewer vents are closed. No water leaks can be found anywhere and believe me I have looked. Doubletree told me two years ago it was from being on the ocean. NOT. We are non smokers and very meticulas about leaving camper spotlessly clean. Any ideas?
__________________
__________________
KEN
2007 Elite Suites 38 RL3 # 3633
2001 Chevy Dually 3500
|
|
|
08-07-2010, 09:44 AM
|
#2
|
Senior Member
Join Date: Aug 2006
Location: Tuttle Oklahoma
Posts: 194
|
When I had that problem I found two things. There was a water leak on my sink drain and the drain hose for the fridg was leaking.
Okie
__________________
__________________
Okies on the road
15 Columbus 381FL
08 F450
|
|
|
08-07-2010, 11:13 AM
|
#3
|
Member
Join Date: Aug 2007
Posts: 89
|
Re: Musty smell
Where is the drain hose for the Fridge?
__________________
KEN
2007 Elite Suites 38 RL3 # 3633
2001 Chevy Dually 3500
|
|
|
08-07-2010, 01:31 PM
|
#4
|
Senior Member
Join Date: Aug 2006
Location: Tuttle Oklahoma
Posts: 194
|
Look in the back of the fridg inside and see a little ledge to catch the water when you defrost. You will find a little hose there. It goes out the back of the fridg and outside the trailer. check out there to be sure it goes out the grill behind the fridg. Mine was stuck inside and the water from it went back in and settled under the fridg. It caused mold and mildew.
Okie
__________________
Okies on the road
15 Columbus 381FL
08 F450
|
|
|
08-07-2010, 02:19 PM
|
#5
|
Site Team
Join Date: Sep 2005
Location: Where we park it
Posts: 2,838
|
musty smell
The water in the sink drain trap could be moldy--could try water/bleach down that. Also, if no water in the trap, grey tank smell might be noticeable. Same for the shower and lav drains.
Joe
__________________
2016 Tiffin 40 QBH
2015 38RSSA, traded
2005 TK3 #1869, 10 yrs of memories,
2017 F450 KR--one more Ford is it
2009 F450 4x4-died; 2010 F450-retired
|
|
|
08-08-2010, 09:31 AM
|
#6
|
Senior Member
Join Date: Mar 2007
Location: Qc. Canada
Posts: 206
|
The under-belly coroplast is far from sealed-up.
Driving in the rain can cause water to get up into the insulation that insulates the under floor area.
Once there is water up in there, you never actually see it, but after a while you can smell it.
The 1st. time I dropped the under-belly liner I was surprised to see the wet insulation, and the source of a mouldy odor.
I pulled out all the wet / damp insulation, replaced it with new, dry insulation, then tried to seal-up the under-belly liner.
I used caulking & black duct tape.
No more smell.
Check your 2 rear storage compartments as well because they can get damp inside depending on various situations.
Rick
__________________
2007 Carriage ROYALS INTERNATIONAL MONARCH 38
no truck yet…but looking
|
|
|
08-24-2010, 11:59 PM
|
#7
|
Junior Member
Join Date: Oct 2007
Location: Seattle
Posts: 15
|
We have had the problem for 3 years. I do believe it is from water leaks which I believe I have fixed, but the smell does not go away. Source of major leaks was the front cap roof seam. Water did make its way down to the belly. Wouldn't the insulation dry out and the smell go away. Its driving us nuts.
__________________
07 MS 36TK3
08 F350 DRW
|
|
|
08-25-2010, 07:46 AM
|
#8
|
Member
Join Date: Aug 2010
Location: Salt Springs, Florida
Posts: 89
|
We had a similar problem after we had our unit in for reapirs and the fridge was off and got a little moldy. We found the problem to be mold around the door seal for the fridge. After many cleanings with bleach it finally has gone away.
__________________
2007 38Rl3 MS
2005 Chevy 3500 4x4 5" Exhaust, Edge Attitude Tuner, Airaid Intake, Air Bags, Rancho Shocks, Hellwig Big Wig Sway Bar
|
|
|
08-25-2010, 07:52 AM
|
#9
|
Senior Member
Join Date: Jun 2006
Location: Boydton, VA
Posts: 443
|
" Source of major leaks was the front cap roof seam".....that was caused by a major defect in design, did you bring that to the attention of DRV ? Did they repair and mitigate the damage caused by the water ?
We managed to catch our roof seam defect just before a major rainstorm in '06...your '07 may have been affected by the same error in design.
My belief, which DRV disputed, was that the cap was not engineered correctly, the design did not allow the front cap to be secured down to the deck of the roof properly, and the cap would pop up, leaving a gap of 1"....
Regards
Gemstone
__________________
No longer on the road.
|
|
|
08-27-2010, 07:39 AM
|
#10
|
Member
Join Date: Aug 2007
Posts: 89
|
Roof Seam
Was it the front or back cap and how did you know it was the roof seam? I can see nothing that looks like it may be leaking on the roof. Our roof on the Elite is metal, would that make a difference.
__________________
KEN
2007 Elite Suites 38 RL3 # 3633
2001 Chevy Dually 3500
|
|
|
08-27-2010, 07:31 PM
|
#11
|
Senior Member
Join Date: Jun 2006
Location: Boydton, VA
Posts: 443
|
Never heard of a metal roof on an Elite....
The problem on mine was that the front cap did not seem like it was formed correctly...the bend at the top was to slight, it would not allow the front cap to contact the roof deck properly. The trained monkeys at the factory just snugged it down with screws, over-torquing most of them and breaking them off....no problem, a little caulk would fix that...
Send me your e-mail address, I'll send you some photos of before and after.
Regards
Gemstone
__________________
No longer on the road.
|
|
|
08-28-2010, 10:45 PM
|
#12
|
Site Team
Join Date: Sep 2005
Location: Where we park it
Posts: 2,838
|
That would be a fiberglass roof?
__________________
2016 Tiffin 40 QBH
2015 38RSSA, traded
2005 TK3 #1869, 10 yrs of memories,
2017 F450 KR--one more Ford is it
2009 F450 4x4-died; 2010 F450-retired
|
|
|
08-29-2010, 10:03 AM
|
#13
|
Member
Join Date: Aug 2007
Posts: 89
|
kmcfar1948@aol.com
Would you be able to see where the seam might be leaking?
__________________
KEN
2007 Elite Suites 38 RL3 # 3633
2001 Chevy Dually 3500
|
|
|
08-29-2010, 08:32 PM
|
#14
|
Senior Member
Join Date: Jun 2006
Location: Boydton, VA
Posts: 443
|
In my case, yes....no problem seeing the 1" gap where the leak (more like a flood) would have occurred, had I not found the defect prior to the monsoon.
mcfarlak...I sent you a link to the photo's.
Regards
Gemstone
__________________
__________________
No longer on the road.
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|